quattroworld.com Forums: Things that will fail on your AAN and strand you on the side of the road

All messages | Search Forums | Return to UrS4/UrS6/S2/RS2

Things that will fail on your AAN and strand you on the side of the road
Posted by: UrS4boy (137) on 2012-11-01 05:50:56 In Reply to: ENGINE posted by EDIGREG on 2009-10-10 12:54:20	Share \| Report

The idea is preventative maintenance.

Click HERE

Thread:

Frequently Asked Questions (FAQ), Procedures and Resources... - EDIGREG 2009-10-10 12:50:56 (220134 views) (Sticky)
- FULL OF FAIL - ThetaTau87 2011-05-30 18:40:10 (71442 views)
- BOSCH MOTRONIC ECU - quattron8-JC 2011-11-29 08:37:35 (84474 views)
  - Determining long term mixture trends and mixture codes (Lean vs. Rich) on AAN ECU's - GreenMachine 2022-06-01 14:15:06 (3007 views)
  - Bob Myers ECU opening procedure (as a pdf) - ThetaTau87 2014-03-07 06:56:45 (60481 views)
  - Moisture trap (fuel condenser) info - ThetaTau87 2017-03-01 00:32:41 (69671 views)
  - AAN Motronic ECU device list and T55 connector pin-outs (c/w wire colours) and hyperlinks - UrS4boy 2012-03-02 02:28:06 (82023 views)
    - ABY pin-outs from S2Central.net (NOW as a 4 pg. pdf for your use) - UrS4boy 2017-10-22 10:22:01 (20321 views)
  - Aftermarket Chip Tune Identification by Vendor - quattron8-JC 2011-11-29 08:39:22 (83925 views)
    - Wetteraeur Stg 1 - Neacail 2017-01-07 18:51:00 (25786 views)
    - Stock Chip Numbers and orientation - UrS4boy 2012-08-19 04:29:34 (74788 views)
    - Eiche 3bar(MTM 1+ clone) chipset - UrSobsessed 2011-11-30 02:08:21 (82128 views)
    - MTM Stage 1+ - quattron8-JC 2011-11-29 09:48:47 (87680 views)
      - Additional MTM chip info with info about Hoppen Motorsports involvement - UrS4boy 2012-03-19 08:19:07 (79202 views)
    - TAP (Total Audi Performance) Stage 1 - 4 - quattron8-JC 2011-11-29 08:59:46 (86586 views)
- VEMS - EDIGREG 2011-09-15 04:18:52 (82004 views)
  - Boost tuning with the new 1.2.9+ boost control system - zeet 2013-06-23 21:06:58 (67145 views)
  - Setting up N80 provision in VEMS - UrSobsessed 2012-04-28 09:53:13 (82834 views)
  - Tuning VEMS idle/cranking settings: - EDIGREG 2011-09-15 04:22:30 (83445 views)
  - VEMS Fuel Tuning Guide - EDIGREG 2011-09-15 04:20:21 (82475 views)
  - VEMS installation instructions: - EDIGREG 2011-09-15 04:19:23 (83874 views)
- UrS Chassis Map: - EDIGREG 2011-02-01 04:30:38 (88738 views)
  - Updated link - SpeedTek 2015-11-30 12:47:37 (35065 views)
- UrS Engine Bay Device Map: - EDIGREG 2011-02-01 04:30:12 (88437 views)
  - Updated link - SpeedTek 2015-11-30 12:46:49 (35238 views)
- THE ORIGINAL AND UPDATED ENGINE BAY DEVICE MAP AND ITS 35+ LINKS TO RELATED INFO - UrS4boy 2010-03-09 23:16:13 (97470 views)
- THE ORIGINAL URS-CAR CHASSIS AND SYSTEM MAP AND ITS 28+ LINKS TO MORE INFO - UrS4boy 2010-03-09 23:13:58 (95020 views)
- CRUISE CONTROL - GreenMachine 2009-10-25 15:36:59 (91568 views)
  - Cruise Control Module Repair - GreenMachine 2017-08-28 11:05:04 (22284 views)
  - Some Cruise Control Mechanical PNs - UrS4boy 2011-10-15 03:56:40 (83674 views)
  - Cruise Control: "The whole nine yards..." - EDIGREG 2011-09-15 04:18:21 (84237 views)
    - More Cruise Control Diagnostics - GreenMachine 2022-11-27 13:02:31 (1995 views)
    - Cruise switch fault finding - Audi MA8 2016-12-03 17:01:10 (26189 views)
  - Cruise Switch Diagnosis/Repair: - EDIGREG 2011-09-15 04:16:16 (82290 views)
    - Cruise Control Switch - Complete Rebuild with Pictures - k2exoman 2016-04-18 11:11:16 (37030 views)
  - Repairing the cruise control module: - EDIGREG 2015-05-15 03:31:02 (83918 views)
    - PCB Conformal Coating Removal - chiil 2020-09-20 19:42:00 (6583 views)
  - Cruise Control Vent Valve Repairing - GreenMachine 2009-10-25 15:38:40 (94403 views)
- VAG-COM / DIAGNOSTICS - EDIGREG 2009-10-11 03:16:47 (91772 views)
  - VCS User Manual - TheCrispyNoodle 2017-07-10 22:35:38 (21627 views)
  - Three DIY Methods of Retrieving ECU fault codes that we should all know about - UrS4boy 2015-12-29 11:42:00 (35216 views)
  - ECU removal procedure pdf - UrS4boy 2011-02-05 02:56:10 (86424 views)
    - Bob Myers ECU opening procedure (as a pdf) - UrS4boy 2011-02-05 03:07:37 (85075 views)
  - Link to on-line VAG-COM codes - UrS4boy 2010-09-05 02:44:40 (88211 views)
    - vag com codes - loadtoad24 2019-01-13 18:14:21 (13123 views)
  - Resetting service intervals and oil change warnings (Ln.1, Ln.2, flashing oil light respectively) - boxflares 2010-04-05 13:51:25 (95124 views)
  - Reading ECU fault codes: - EDIGREG 2009-10-25 13:18:43 (91790 views)
  - Ross-Tech Fault Codes Database: - EDIGREG 2009-10-11 14:24:18 (90895 views)
  - 20vt ECU Fault Codes and Symptoms: - EDIGREG 2009-10-11 03:20:03 (99595 views)
- WHEELS / TIRES - EDIGREG 2009-10-10 12:58:57 (90149 views)
  - Best Wheel & Tire Comparison Site - changed recently but still good - see new EDIT - vbmica 2010-06-27 00:08:09 (90518 views)
  - Tire Size Calculator - El Nino Loco 2010-02-02 04:49:45 (90801 views)
  - UrS Wheel Gallery: - EDIGREG 2009-10-10 13:20:10 (95464 views)
- WIPER SYSTEM - EDIGREG 2009-10-10 12:58:45 (89611 views)
  - Avant rear wiper & washer function repair - urs6Josh 2020-08-24 10:36:15 (6722 views)
  - Urs6 Avant Rear Wiper Motor Rebuilding - GreenMachine 2019-12-09 13:43:11 (10044 views)
    - Urs6 Avant Rear Wiper Motor Sprayer Tube and End Replacement - GreenMachine 2019-12-09 13:46:58 (10051 views)
  - Skipping or missing while clearing wiper fix by "fastscirocco" -verified to work! - ImQuattro�� 2010-12-16 11:31:19 (87050 views)
  - Variable intermittent wiper relay: - EDIGREG 2010-09-08 09:30:05 (87746 views)
    - Some more info... - UrSobsessed 2011-11-10 13:31:13 (79765 views)
  - Windshield/Headlight washer reservoir R & R - boxflares 2010-05-08 23:49:03 (91962 views)
- TOOLS - EDIGREG 2009-10-10 12:57:42 (89385 views)
  - Audi Special Tools and Equipment Program - sbitch 2010-06-05 16:37:24 (89895 views)
- TECHNICAL REFERENCE - EDIGREG 2009-10-10 12:57:24 (89897 views)
  - 01E workshop manual - grillage 2016-02-15 04:28:31 (33528 views)
  - ANN 20VT (& V8) Motronic Self Study Guide 1992 VAG 143 - sbitch 2009-11-10 03:11:51 (92416 views)
- SUSPENSION - EDIGREG 2009-10-10 12:56:53 (90239 views)
  - Suspension Refresh Parts List - check against your own car, but this will get you started - lliejk 2016-03-04 07:24:27 (34491 views)
  - Simplified C4 UrSF Front Lower Control Arm (LCA) Replacement DIY - UrS4boy 2015-11-06 16:24:22 (36551 views)
  - CV Joint - Dis-assembly - Cleaning - Lubrication - Reassembly - lliejk 2015-07-08 12:06:15 (39607 views)
  - Lower control arm - replacement procedure - cosmo 2015-01-03 06:45:23 (46871 views)
    - Mirror? - Jehannum 2019-04-16 12:18:49 (11948 views)
      - Audi Urs4 lower control arm replacement - 12v.org (mirror) - k2exoman 2019-04-16 16:15:17 (12387 views)
        
        Thank you! - Jehannum 2019-04-16 19:44:46 (11840 views)
  - Front suspension noise caused by new front strut bearings that are too thin - KBATTPO 2013-08-29 13:54:28 (64779 views)
  - Carbon Fiber heim joint part numbers for sway bar end links from McMaster-Carr. - ThetaTau87 2013-04-03 07:22:35 (68447 views)
  - Wheel bearing housing 101 - ThetaTau87 2013-03-20 09:01:44 (69096 views)
  - Front Suspension PNs, Springs alternatives and Alignment Solutions - ThetaTau87 2013-03-20 09:00:11 (70821 views)
  - Rear Suspension PNs and info - ThetaTau87 2013-03-20 08:25:06 (69968 views)
    - Rear Suspension mounts / bushing P/Ns for NLA OEM mounts. - GreenMachine 2024-01-30 12:52:57 (181 views)
  - Replacing rear subframe mounts with Apikol poly bushings without removing subframe from car. - ThetaTau87 2013-03-11 19:40:55 (75339 views)
  - Bilstein gland nut (AKA ring nut or strut cap) part numbers. Seal and installation tool PNs also. - ThetaTau87 2013-03-01 10:32:52 (73545 views)
    - P/N Change - A2QSHIP 2016-09-14 09:27:30 (27373 views)
  - ARSB Install Instructions - urs6ville 2012-09-14 08:55:20 (73220 views)
  - Camber plate modification for lowered cars, by Igor Kessel - EDIGREG 2012-08-15 15:11:31 (76705 views)
    - Some notes for the Igor Kessel top mount mod plus other procedures - TheCrispyNoodle 2022-01-12 14:26:15 (3793 views)
  - How To Rebuild Your Foremost Rear Trapezoidal Arm Mounts With Polyurethane Bushings - slater 2012-07-10 05:43:28 (75707 views)
  - Front Subframe Bushing - Removal & Installation Procedure - S4Pirate 2011-05-18 02:56:34 (91178 views)
  - Front suspension torque specs - Brdman* 2011-01-23 02:07:30 (91324 views)
    - Complete Front Suspension Torque Specs and Part Numbers - UrS4boy 2012-03-01 01:43:15 (82032 views)
  - Bilstein part numbers: - EDIGREG 2010-09-23 02:29:48 (88685 views)
  - Suspension Rebuild - quattro20v 2010-02-21 15:05:07 (108516 views)
  - Rear Subframe Parts Diagram and Torque Specs: - EDIGREG 2009-10-10 14:53:27 (98183 views)
    - Suspension torque spec values - blackghost 2014-08-04 12:29:02 (53078 views)
- STEERING - EDIGREG 2009-10-10 12:56:42 (89390 views)
  - How the Power Steering System Works - AustinEngy 2021-07-03 14:58:04 (5028 views)
  - Steering Rack Replacement - cosmo 2015-01-03 06:47:41 (46902 views)
    - Notes regarding steering rack lines with different banjo bolts - k2exoman 2016-11-14 04:51:40 (28094 views)
  - Servotronic Power Steering Rack, Connector, and bracket replacement info - ThetaTau87 2013-03-20 09:27:34 (69247 views)
  - Power Steering and Brake Pump R&R DIY by Boxflares (Steve M) - ThetaTau87 2013-03-20 08:49:43 (69238 views)
  - UrS-car Servotronic Control Module PNs and Locations info. - ThetaTau87 2013-03-20 08:47:37 (68203 views)
  - Steering Wheel Swap info - ThetaTau87 2013-03-20 08:35:36 (69047 views)
  - Drag Link Socket for "X-Plug" Info - GreenMachine 2011-07-05 19:21:49 (82809 views)
  - Hydraulic Steering Pump "X-Plug" and O-Ring Part Number - GreenMachine 2011-07-05 19:20:05 (83083 views)
    - The substitute O-ring part number and source for the NLA X-plug. - KBATTPO 2019-01-13 20:33:39 (13157 views)
  - PS hydraulic system flush: - EDIGREG 2010-05-10 11:57:22 (90620 views)
  - PS pump R & R (with input from BilltheCat) - boxflares 2010-05-09 00:03:48 (95766 views)
  - Steering Rack R&R - sbitch 2009-12-31 03:40:00 (90410 views)
    - UrS6 Steering Rack R & R - sbitch 2010-06-01 08:55:12 (90118 views)
  - Steering Rack Preload Adjustment: - EDIGREG 2009-10-11 12:28:28 (91184 views)
  - Steering Damper R&R: - EDIGREG 2009-10-10 15:23:04 (90451 views)
- PART NUMBERS / SOURCES - EDIGREG 2009-10-10 12:56:32 (90413 views)
  - Some VAG Audi PNs to Bosch PNs cross-overs - UrS4boy 2011-02-05 03:13:31 (84715 views)
  - TUNERS / AFTERMARKET PARTS: - EDIGREG 2009-10-10 13:12:30 (89805 views)
    - Iroz Motorsport - EDIGREG 2013-11-07 04:58:22 (61516 views)
    - Avalon Motorsports in Denver, CO - scarman 2010-02-15 01:56:58 (90459 views)
    - EFI Express - EDIGREG 2009-10-10 14:58:42 (90710 views)
    - MRC (Mihnea) / Chips-ur-s - EDIGREG 2009-10-10 14:26:51 (90728 views)
    - Intended Acceleration (IA) - EDIGREG 2009-10-10 14:26:07 (90220 views)
    - ECS Tuning - EDIGREG 2009-10-10 14:25:29 (90078 views)
    - Hoppen Motorsports (MTM) - EDIGREG 2009-10-10 14:24:58 (90425 views)
    - Apikol - EDIGREG 2009-10-10 13:17:52 (90332 views)
    - 034 Motorsport - EDIGREG 2009-10-10 13:16:21 (89982 views)
  - ONLINE PARTS SOURCES (OE): - EDIGREG 2009-10-10 13:11:59 (89831 views)
    - IABED INDUSTRIES - scarman 2020-10-28 16:30:26 (6665 views)
    - EMI Parts - stuffinder 2016-05-21 05:42:25 (30267 views)
    - FCP EURO Genuine and OEM European parts - MarvelousS4 2015-07-09 16:19:17 (39346 views)
    - DCH Millburn Audi online - NJ - Contact Carson Heter for forum discount - Quattro_JC 2013-11-03 05:45:07 (61390 views)
      - Carson is no longer affiliated with this dealership, but the discount program he set up is still - scarman 2015-10-02 14:02:15 (35640 views)
        
        They no longer have the same e-commerce website as before but the latest web addy as of Aug 2017: - mannywdc 2017-09-01 08:02:39 (20359 views)
    - Hella online parts search by make and model. - TheCrispyNoodle 2013-06-11 03:58:49 (65925 views)
    - Busdepot - habe Ich gesagt 2013-03-15 08:53:49 (67673 views)
    - Bosch Online Automotive Catalogue - TheCrispyNoodle 2012-07-31 10:07:12 (73402 views)
    - Boge - Sachs - Lemforder Online Cat - TheCrispyNoodle 2012-02-23 17:17:50 (77374 views)
    - Rocky Mountain European, Englewood, CO - nunya 2012-01-19 04:23:01 (77914 views)
    - GoWesty Auto Parts - islingtonaudi 2012-01-13 02:28:58 (78107 views)
      - CLOSED - scarman 2015-10-01 17:02:50 (35538 views)
    - All European Auto Supply, Royal Oak, MI - speedydtp247 2011-09-04 13:16:30 (80274 views)
    - Zygmunt Motors in Doylestown, PA - scarman 2010-02-15 01:38:34 (89425 views)
    - Pelican Parts in Southern California - scarman 2010-02-15 01:36:08 (89459 views)
    - Dave Kase brake accumulator recharge/exchange - scarman 2010-02-15 01:15:40 (90035 views)
    - Audi/VW Special Tools Program - scarman 2010-02-15 01:09:29 (87389 views)
    - Force 5 Concord, NH - scarman 2010-02-15 00:55:26 (89640 views)
    - Suncoast Automotive, Sarasota, FL - scarman 2010-02-15 00:44:15 (89100 views)
    - Meadowlands Audi, North Bergen, NJ - scarman 2010-02-15 00:39:25 (89808 views)
      - Audi Meadowlands is a Benzel-Busch dealership in N NJ. They recently changed their discount parts - scarman 2020-08-15 17:44:32 (6758 views)
    - Rector Audi Burlingame, CA - scarman 2010-02-15 00:31:58 (89307 views)
    - Frugal Mechanic - EDIGREG 2009-10-10 14:49:54 (89583 views)
    - For Canadians, especially Western Canada, VM Auto Haus - UrS4boy 2009-10-10 14:43:38 (89665 views)
    - World Impex - EDIGREG 2009-10-10 13:19:06 (89775 views)
    - FAP 99 - EDIGREG 2009-10-10 13:18:36 (89977 views)
    - Autohaus AZ - EDIGREG 2009-10-10 13:15:13 (90320 views)
    - Genuine VW/Audi Parts (Miramar VW/Audi) - EDIGREG 2009-10-10 13:14:29 (90918 views)
      - Name changed to San Diego Audi. Same online parts dept run by Ingrid and Bill. - scarman 2014-03-30 07:48:22 (55709 views)
  - VagCat - EDIGREG 2009-10-10 13:06:21 (89887 views)
  - C4 Parts List: - EDIGREG 2009-10-10 13:04:31 (90560 views)
    - Audi Parts List *Very User Friendly* - GreenMachine 2013-06-13 13:52:44 (67186 views)
- INTERIOR / INSTRUMENTATION - EDIGREG 2009-10-10 12:55:50 (90084 views)
  - Replacing HVAC Head Unit Voltage Regulators - IslandUrS6 2023-01-31 11:50:33 (1622 views)
  - Stalk Switches Repair - AZierer_S4 2021-12-14 15:13:43 (3948 views)
  - Meguiar's PlastX polish to remove minor scratches on the instrument cluster. - ThetaTau87 2021-02-12 12:53:58 (5610 views)
  - Evaporator cleaning & recirc flap repair - urs6Josh 2020-08-22 20:05:11 (6791 views)
  - Cluster repair--Oil temp & Voltage ---write-up & pics - urs6Josh 2020-08-19 17:16:18 (7191 views)
  - '95 Urs6 Instrument Cluster Chime/Speaker Replacement - GreenMachine 2019-06-13 01:00:28 (11844 views)
  - C4 UrS sedan rear headrest removal - Harrison 4.2 2018-09-25 17:35:00 (14700 views)
  - Retrofitting a voltmeter from an UrS6 into and UrS4. - UrSobsessed 2015-03-01 10:36:52 (43607 views)
    - Dead Link (Link enclosed) - GreenMachine 2020-06-25 16:17:47 (7268 views)
  - C4 Dash Trim Removal DIY - UrS4boy 2015-02-18 05:53:27 (43988 views)
  - Side View Mirror Switch Bulb Replacement - GreenMachine 2015-01-26 20:02:18 (44880 views)
  - 1997 m/y power seat diagram with translation and comments. - KBATTPO 2014-12-15 18:32:44 (46515 views)
    - The link in this post needs to be fixed. Looks like it directs to an 'edit' link. - Dave Doolittle 2021-11-08 19:21:13 (4016 views)
      - Google recently implemented some changes to their Drive and broke many links. Should be working now. - KBATTPO 2021-11-08 20:09:12 (3958 views)
  - UrS Instrument Cluster External Differences - ThetaTau87 2013-03-20 09:21:15 (68957 views)
  - Fix broken plastic parts with this plastic repair kit. - PLANETARY4 2013-02-25 17:14:02 (69067 views)
  - Manual roller blind installation - boxflares 2012-04-11 14:33:44 (77070 views)
  - Installing a manual rear window roller blind (sedans only) - boxflares 2012-03-12 00:56:23 (77484 views)
  - Ordering quattro script cloth from Audi Tradition - boxflares 2012-02-23 23:58:37 (79266 views)
  - Rain tray & sunroof glass removal w/o dropping the head liner. - ImQuattro�� 2011-11-12 04:28:34 (80399 views)
    - Sunroof R&R, with pictures - boxflares 2012-04-11 14:38:08 (79221 views)
  - Fix Your Saggy Seat Back Net - audi/s/scott 2011-02-11 02:16:46 (85192 views)
  - Sunroof control panel repair - MatLax 2010-11-05 03:42:21 (86921 views)
  - HVAC climate control unit button repair - ThetaTau87 2010-08-11 09:22:42 (97159 views)
  - Avant tailgate trim removal - rechlin 2010-07-10 04:14:00 (88032 views)
  - Child seat restraint part number and installation tech bulletin - boxflares 2010-06-12 00:37:52 (88055 views)
  - Instrument Cluster (IC) 2W and 1.2W bulb locations. - turbos4audi 2010-03-31 02:10:51 (97063 views)
    - IC Light Diffusers (red) bulb covers - speedydtp247 2017-05-15 20:07:48 (22523 views)
    - This post incorrectly lists the two autocheck bulbs as 2W. They're actually 1.5W. - GreenMachine 2015-11-10 04:41:18 (35038 views)
      - 1.5W bulb part # 62111391260 - speedydtp247 2015-11-12 15:07:53 (34796 views)
  - Door Panel Removal - Jimmy Pribble 2010-03-27 14:55:28 (91331 views)
  - Headliner fabric replacement DIY. LONG and lots of detail: - turbos4audi 2010-03-22 04:57:21 (91300 views)
  - How to permanently disable the Auto Check brake wear indicator: - EDIGREG 2010-03-09 16:54:50 (92774 views)
    - Reversible jumper install to override brake pad auto check - quattron8-JC 2012-09-29 14:02:08 (75066 views)
    - Additional detail and picture for Auto Check brake wear indicator disable procedure - ThetaTau87 2011-08-11 05:16:26 (83285 views)
  - Trip Computer Harness & 92 Retrofit of Trip Computer/Stalk into 93 UrS - deephouse 2010-03-09 06:49:17 (92852 views)
  - Lobotomizing the autocheck lamp warning module (link inside) - vtlew 2009-11-15 11:44:35 (90692 views)
  - HVAC LCD/CONTROL R&R (sticky button syndrome) - sbitch 2009-11-10 03:03:23 (89887 views)
  - Link to Tom M (4Driver4)'s excellent seat heater element replacement DIY - UrS4boy 2009-10-13 17:06:08 (90590 views)
  - DIY Carbon Fiber CC Surround: - EDIGREG 2009-10-10 16:09:45 (91602 views)
    - Updated Link - AZierer_S4 2021-12-28 21:44:11 (3700 views)
  - ECU Removal Procedure: - EDIGREG 2009-10-10 15:19:28 (89759 views)
    - Opening the ECU Procedure - speedydtp247 2010-12-21 22:40:50 (87491 views)
  - Front Console Removal Instructions: - EDIGREG 2009-10-10 15:14:12 (90567 views)
  - Outside Temp Display Bulb Replacement: - EDIGREG 2009-06-09 17:00:00 (90908 views)
  - Rear Console Removal Instructions: - EDIGREG 2009-10-10 14:40:48 (89860 views)
  - 3-spoke Sport Steering Wheel Conversion Instructions: - EDIGREG 2009-10-10 14:38:45 (92431 views)
    - Some early 1995 UrS6 cars with a 4-spoke wheel may not need clockspring or column cover changes - Fonzinator 2013-08-04 09:14:10 (63999 views)
    - ^^Steering Wheel 4A0419091BA from UrS6 or 96-97 A4 with the sport steering wheel. - UrS4boy 2009-11-01 11:34:18 (91885 views)
  - Seat Heater Switch Bulb Replacement: - EDIGREG 2009-10-10 13:24:17 (90018 views)
  - Instrument Cluster (IC) Lamp Replacement: - EDIGREG 2009-10-10 13:22:09 (91348 views)
- IGNITION - EDIGREG 2009-10-10 12:55:22 (89242 views)
  - Ignition Key part number 443837220 - habe Ich gesagt 2012-10-26 00:57:03 (71961 views)
  - Ignition Switch Replacement: - EDIGREG 2012-06-04 16:24:51 (76021 views)
    - Part no suffix 'A' = manual and suffix 'B' = automatic - TheCrispyNoodle 2014-09-16 04:40:42 (50540 views)
  - How To: Replace the Ignition Lock Cylinder Assembly - urs6ville 2011-09-04 10:02:07 (80943 views)
  - Power to Ignition Coils - S64 Thermal Breaker (Circuit Breaker) - Emerald-UrS4 2011-07-19 11:06:33 (83085 views)
  - Detailed Power Output Stage (POS) info including using the spare channel - EDIGREG 2011-01-31 15:13:19 (85278 views)
  - AAN ignition coil info including POS and Cam Sensor info and Diagnostics - EDIGREG 2011-02-08 01:21:54 (86382 views)
  - Link to a pictoral G40 Cam Position Sensor (CPS) replacement procedure - UrS4boy 2009-10-11 12:53:41 (91319 views)
  - 1.8t Coil Pack Conversion: - EDIGREG 2009-10-10 16:06:25 (91712 views)
- GENERAL INFORMATION - EDIGREG 2009-10-10 12:55:03 (89178 views)
  - The monthly reminder post with all its links to things that we shouldn't forget. - UrS4boy 2013-07-19 22:49:10 (66147 views)
  - Things that will fail on your AAN and strand you on the side of the road - UrS4boy 2013-07-19 14:31:48 (67088 views)
  - Some 20V Turbo Inline 5 Audi Engine History - UrS4boy 2012-09-15 12:43:28 (75200 views)
  - UrS Model Year Changes 1992 to 1997 - with North America bias - UrS4boy 2012-03-11 11:36:20 (77482 views)
  - 1995 U.S. Market S6 Volume Records: - oldsklaudidub 2012-02-27 08:32:40 (78537 views)
  - vagcat.com - Free online Audi/VW parts catalog - UrSobsessed 2011-10-02 05:44:41 (81481 views)
    - Vagcat website is defunct. This 7zap catalog is the best source other than ETKA. - scarman 2017-02-25 05:57:38 (24038 views)
  - RE: Importing RS2/S2s - Mcstiff 2010-11-22 06:30:53 (86139 views)
  - Decoding UrS VINs - UrS4boy 2010-11-06 04:58:27 (86841 views)
  - S-cars.org DIY Link Page. Lots of good info to download and save - UrS4boy 2009-10-13 17:08:06 (91148 views)
  - UrS4/UrS6 Technical Specifications: - EDIGREG 2009-10-10 15:43:37 (91346 views)
  - Buyer's Guide: - EDIGREG 2009-10-10 15:30:10 (90645 views)
- FUEL SYSTEM - EDIGREG 2009-10-10 12:54:50 (89235 views)
  - Alternative to Compression fittings and Nylon Fuel Line. Niccop (Nickel-Copper Fuel Line) - GreenMachine 2021-04-21 21:43:31 (6234 views)
  - Fuel Level sending or Guage or fuel light works intermittently. Repair inside. - urs6Josh 2020-09-08 10:36:36 (6566 views)
  - Mance's VAP Fuel Line DIY Replacement Procedure - 1995S6er4life 2015-03-06 06:16:53 (43242 views)
    - UPDATED LINK -January 16, 2017 - UrS4boy 2017-01-16 06:30:50 (25012 views)
  - DIY instructions for adding a battery-to-fuel pump relay - ThetaTau87 2013-03-20 09:12:48 (68707 views)
  - Fuel Line PN and preventative maintenance info - ThetaTau87 2013-03-20 09:09:04 (68314 views)
  - FredM's Fuel Line Maintenance DIY - UrS4boy 2012-07-10 04:18:45 (74302 views)
    - Alternative to Compression fittings and Nylon Fuel Line. Niccop (Nickel-Copper Fuel Line) - GreenMachine 2021-04-21 21:36:11 (3885 views)
  - Power to the Injectors - S72 Thermal Breaker (Circuit Breaker) - Emerald-UrS4 2011-07-26 00:20:35 (82450 views)
  - Fuel System including Fuel Pressure Regulator Info - EDIGREG 2011-01-31 15:11:59 (86198 views)
    - Source for "A" FPR replacement - GreenMachine 2018-12-27 21:33:17 (13121 views)
  - J17 Fuel Pump Relay Information - EDIGREG 2011-01-31 15:10:11 (86311 views)
  - Fuel Injector Info - EDIGREG 2011-01-31 15:06:13 (85168 views)
    - Stan Weiss's Fuel Injector Table - UrS4boy 2012-05-13 06:22:40 (75688 views)
  - Fuel Filter Info - EDIGREG 2011-01-31 15:05:51 (85292 views)
  - G6 Fuel Pump Info - EDIGREG 2011-01-31 15:05:29 (85003 views)
  - Bosch "044" pump DIY install - UrSobsessed 2009-11-20 13:35:51 (109248 views)
  - Fuel Pump Testing Procedure: - EDIGREG 2009-10-10 15:03:20 (90174 views)
  - Fuel Pump Replacement: - EDIGREG 2009-10-10 13:26:35 (91940 views)
    - Updated version. - UrS4boy 2017-01-29 13:51:28 (24933 views)
- EXHAUST - EDIGREG 2009-10-10 12:54:32 (89117 views)
  - Stromung Alternative Downpipe Gasket (Seals 10x better than Vibrant) - GreenMachine 2022-06-01 12:51:18 (2791 views)
  - All the components of the C4 UrS exhaust system, head to tailpipe - UrS4boy 2012-09-15 12:45:01 (74025 views)
  - One solution to eliminate the drone present with many custom exhaust systems - MatLax 2012-09-15 09:51:00 (74228 views)
  - The history of Stromung exhaust for the C4 chassis S car - es-car-go 2010-05-22 13:28:53 (91703 views)
  - This note covers installation of Stromung Gen 5 - es-car-go 2010-05-22 13:20:39 (89617 views)
- ENGINE - EDIGREG 2009-10-10 12:54:20 (89638 views)
  - Analogue Boost Gauge 101 - options, locations and installation suggestions - UrS4boy 2017-09-03 22:17:04 (20820 views)
  - Swapping plastic to metal crossover pipes. Be sure to grab these two brackets for the install: - GreenMachine 2017-06-23 14:49:48 (21683 views)
  - Testing for Boost Leaks - Cash68 2017-01-06 07:10:14 (25638 views)
  - Engine Harness Pdf - Passenger compartment with link to engine compartment info - UrS4boy 2016-06-01 11:33:23 (30063 views)
  - Coolant Flush Procedure - jstoker 2015-10-15 07:30:45 (36917 views)
  - Intake Manifold Removal - GreenMachine 2015-07-31 14:14:25 (38486 views)
  - AAN Oil Pressure Sender, Switches, Wiring and Check Valves (with UPDATES) - skiguy 2015-03-27 11:07:56 (43028 views)
  - Motor and Transmission Mount Replacement - AudiCoupeGT 2014-12-10 16:41:43 (49205 views)
  - G69 / F60 Throttle valve position potentiometer /idle switch repair - KBATTPO 2014-08-15 04:08:21 (52174 views)
  - Victor Reinz engine gasket and seal part numbers for Audi 2.2T (also includes head bolt kit PN) - ThetaTau87 2014-02-11 19:00:28 (57848 views)
  - 034 Garrett turbo coolant line kit modifications - ThetaTau87 2014-02-04 16:15:46 (57912 views)
  - Bosch Starter Rebuilding - GreenMachine 2013-12-31 13:20:27 (59101 views)
  - Adapter PNs to install an oil pressure gauge - ThetaTau87 2013-11-05 15:00:00 (64947 views)
  - Turbo Coolant and Oil Feed and Return Lines - UrS4boy 2013-06-24 10:51:06 (66003 views)
  - By-pass Valve (BPV) Info (AKA Diverter Valve) - ThetaTau87 2013-03-20 12:35:39 (68370 views)
  - Potential solutions to why your AAN-powered UrS isn't starting - UrS4boy 2012-11-01 05:54:01 (72155 views)
  - Things that will fail on your AAN and strand you on the side of the road - UrS4boy 2012-11-01 05:50:56 (72227 views)
  - K24-7000 OE Turbo and K24-7200 Turbo info including disassemby pdf - UrS4boy 2012-10-27 08:36:41 (73108 views)
  - upgrade to Setrab oil cooler - urs6ville 2012-08-02 07:05:17 (74625 views)
    - Installing a larger oil cooler in the stock location. - ThetaTau87 2014-03-07 06:38:20 (57299 views)
    - Aeroquip Socketless hose and ends in place of braided stailess hose - ThetaTau87 2014-02-11 08:35:21 (57953 views)
    - A couple of links for installation references: - UrSobsessed 2012-08-02 07:16:49 (73184 views)
  - How To: Seal your valve cover gasket, once and for all... - EDIGREG 2012-06-25 08:22:50 (77223 views)
  - C4 AAN starter R&R - boxflares 2012-04-11 14:27:02 (78517 views)
    - Some observations of my own from doing this earlier today, before I forget - TheCrispyNoodle 2018-12-27 14:10:42 (13192 views)
  - AAN Headgasket PNs and changes from paper/metal to metal/metal with Head bolt info link - UrS4boy 2011-08-28 10:30:51 (81592 views)
  - Garrett GT turbo Oil and Water line DIY - quattro.pilot 2011-06-25 10:30:42 (83239 views)
  - 3b head bolt tightening sequence and torque specs - urs6ville 2011-03-16 08:41:42 (84178 views)
  - AAN head bolt tightening sequence and torque specs - urs6ville 2011-03-16 08:41:07 (87191 views)
  - Intake Hose Clamp Specifications for OEM & Samco w/ Breeze CT Part Nums - quattron8 2011-02-05 00:20:29 (84951 views)
  - G71 Manifold Absolute Pressure (MAP) sensor information - EDIGREG 2011-01-31 15:12:56 (85108 views)
  - Firewall Connector Rack Connection Call-out - EDIGREG 2011-01-31 15:12:15 (84576 views)
  - Moisture Trap Info - EDIGREG 2011-01-31 15:11:33 (84874 views)
  - N71 Idle Speed Stabilization Valve (ISV or ISS Valve) Info - EDIGREG 2011-01-31 15:10:28 (85705 views)
  - Crank Position (G4) and Engine Speed Sensor (G28) Info - Function , Location and PNs - EDIGREG 2011-01-31 15:09:48 (86152 views)
  - G61 and G66 Knock Sensor info - EDIGREG 2011-01-31 15:08:48 (84714 views)
    - Servicing G61 & G66 knock sensors - quattron8 2011-05-13 03:34:00 (95274 views)
  - AAN Positive Crankcase Ventilation (PCV) System with revised diagram, PNs and Links - EDIGREG 2011-01-31 15:07:46 (86571 views)
  - Serpentine Belt Info, importance, PNs and R&R procedure - EDIGREG 2011-01-31 15:07:25 (85556 views)
  - G42 Intake Air Temp sensor info - EDIGREG 2011-01-31 15:07:01 (85507 views)
  - G69 / F60 Throttle valve position potentiometer /idle switch information - EDIGREG 2011-01-31 15:06:32 (85092 views)
  - G40 Cam Position Sensor (CPS) info - EDIGREG 2011-01-31 15:04:26 (85825 views)
    - If your CPS plug is falling apart - KBATTPO 2016-05-23 14:03:01 (29830 views)
  - Bypass Valve Info - EDIGREG 2011-01-31 15:04:07 (84928 views)
  - N75 Wastegate Frequency Valve (WGFV) location, function and PN info - EDIGREG 2011-01-31 15:03:10 (86674 views)
  - G70 Mass Air Flow (MAF) sensor info - EDIGREG 2011-01-31 15:02:17 (85240 views)
  - Air Filter Info with PNs including the airbox / MAF cover - EDIGREG 2011-01-31 15:01:02 (84496 views)
  - F96 Altitude/Barometric Pressure Sensor Information - EDIGREG 2011-01-31 15:00:37 (84776 views)
  - G39 Lambda Oxygen Sensor Info and Function with PNs - EDIGREG 2011-01-31 15:00:06 (85009 views)
  - Link to deephouse's Throttle Body Service / install /throttle position switch adjustment DIY - UrS4boy 2010-04-11 07:09:41 (90107 views)
  - Serpentine Belt and Tensioner Info - GreenMachine 2010-03-05 18:06:43 (58880 views)
    - Volvo Serpentine Belt Tensioner Roller with Dust boot. - GreenMachine 2017-12-04 16:32:41 (6037 views)
  - Link to a missing and hesitation diagnostic procedure - UrS4boy 2010-01-20 00:22:30 (90255 views)
  - RS2 MODIFICATIONS: - EDIGREG 2010-01-16 16:43:38 (90414 views)
    - RS2 Manifold Diagram with shortened studs - quattro20v 2016-01-30 10:45:56 (33897 views)
      - Order studs from Marc @ EFIEXPRESS, 034s are too long - Cash68 2019-01-08 21:13:58 (12947 views)
    - RS2 Injector Flow Rates: - EDIGREG 2010-01-16 16:50:37 (92048 views)
    - RS2 Turbo FAQ: - EDIGREG 2010-01-16 16:48:34 (90533 views)
    - RS2 Exhaust Manifold Installation Procedure: - EDIGREG 2010-01-16 16:47:32 (97070 views)
      - Location for the short exhaust studs for RS2 manifold - speedydtp247 2011-12-25 10:18:51 (79283 views)
    - RS2 Part Numbers: - EDIGREG 2010-01-16 16:44:47 (90484 views)
  - Engine Bay Device Map with Links to almost everything the ECU needs for inputs and outputs - UrS4boy 2009-12-28 15:33:27 (90359 views)
  - ANN 20VT (& V8) Motronic Self Study Guide 1992 VAG 143 - sbitch 2009-11-10 03:08:57 (92518 views)
  - ECU Output tests for AAN electrical solenoids: - EDIGREG 2009-10-25 13:08:44 (90275 views)
  - Link to AAN engine manual pdf. - UrS4boy 2009-10-24 04:25:58 (96086 views)
  - ECU pin-out complete with diagram, wire colours and function - UrS4boy 2009-10-11 04:10:47 (90520 views)
    - UrS C4, 200 20VT (3B) and S2/RS2 OBD1 Fault Code access port locations and info - UrS4boy 2012-03-02 02:58:14 (76703 views)
  - Detailed Power Output Stage (POS) info including using the spare channel - UrS4boy 2009-10-11 03:04:29 (120490 views)
    - thanks - greg917 2018-03-15 19:02:31 (17058 views)
    - No power Fuses 28 and 34 - Cristi 2016-04-14 13:23:24 (30707 views)
  - Motronic ECU FAQ: - EDIGREG 2009-10-10 15:38:57 (90253 views)
  - K24/RS2 Turbo FAQ: - EDIGREG 2009-10-05 22:37:14 (92227 views)
  - Timing Belt Replacement Procedure: - EDIGREG 2009-10-10 15:18:16 (92710 views)
  - Motronic ECU Wiring Diagram, Fuses and Sensors: - EDIGREG 2009-10-10 14:48:23 (113876 views)
    - Note: the wiring for the N122 and N127 POS units in the diagram is wrong. The correct wiring is - UrS4boy 2009-10-11 03:08:37 (89890 views)
  - Mass Air Flow (MAF) Sensor (G70) General Information, Cleaning and Testing Procedures: - EDIGREG 2009-10-10 14:44:07 (90071 views)
- EMISSIONS SYSTEM - EDIGREG 2009-10-10 12:53:46 (88794 views)
  - N80 Evaporative Emissions Control Valve and Canister info - EDIGREG 2011-01-31 15:10:49 (85229 views)
  - ANN 20VT (& V8) Motronic Self Study Guide 1992 VAG 143 - sbitch 2009-11-10 03:10:23 (89217 views)
- ELECTRICAL / LIGHTING - EDIGREG 2009-10-10 12:53:22 (89622 views)
  - 150A A8Q Bosch Alternator modification and fitting - TheCrispyNoodle 2021-07-20 01:41:08 (4977 views)
  - Fitting Headlight Relays - TheCrispyNoodle 2019-02-09 13:35:27 (14254 views)
  - Repair the broken plastic bevel gear on the headight adjuster - KBATTPO 2016-01-09 10:34:42 (33187 views)
    - Alternate method utilizing the stock gears with baking soda and super glue. - GreenMachine 2017-12-20 10:19:49 (18623 views)
  - Repair and Maintenance of Window Control Modules including PCBs and mechanical relays - UrS4boy 2015-12-12 10:35:44 (33876 views)
  - Huco 14.6V Voltage Regulator Source for the 110A Bosch Alternator (Urs4 Only) - GreenMachine 2015-05-14 09:04:42 (41913 views)
    - Vemo 14.5V Voltage Regulator Source for the 120A Bosch Alternator (Late '94 Urs4 and Urs6) - GreenMachine 2016-01-23 11:42:05 (35371 views)
  - Urs6 Avant Rear Hatch Wiring Info - GreenMachine 2015-02-17 09:40:36 (43523 views)
  - 113 page pdf C4 UrS4 wiring diagrams - UrS4boy 2013-09-15 11:43:10 (68690 views)
    - 95 s6 avant passager mirror drop/ fog and rear window switches illuminate - Brento50 2019-02-02 10:10:54 (12676 views)
      - Welcome to the forum. This is the FAQ section. It's just a recourse. We reply/post in the main - GreenMachine 2019-02-02 10:35:08 (12635 views)
  - Alternator Troubleshooting/Information - lliejk 2013-06-04 18:04:11 (66267 views)
  - C4 UrS and RS2 Firewall Connector Rack Sensor Connection Call-out with PNs - ThetaTau87 2013-03-20 12:21:54 (67556 views)
  - Battery Information (hold down PNs and comments about height and venting) - ThetaTau87 2017-01-04 22:45:40 (68013 views)
  - C4 UrS Auxiliary Relay, Connector Station and Fuse Panels: their locations and details - ThetaTau87 2013-03-20 08:40:47 (69552 views)
  - Battery Information (hold down PNs and comments about height and venting) - UrS4boy 2011-03-17 05:52:09 (83946 views)
  - 110 Amp and 120 Amp alternator PNs with appropriate Voltage regulator PNs - speedydtp247 2010-11-26 13:02:46 (85882 views)
    - 120A Alternator bearing & regulator service workshop - ImQuattro�� 2011-04-14 12:46:17 (83323 views)
      - 120A late model Voltage Regulator part number interchange - ImQuattro�� 2011-06-02 14:33:02 (83189 views)
  - Voltage Regulator replacement: - EDIGREG 2010-10-31 08:46:31 (86309 views)
  - C4 Starting Circuit Wiring Diagram - ImQuattro�� 2010-10-13 07:12:29 (93158 views)
  - How to remove and reinstall tail light - Fonzinator 2010-05-31 09:32:11 (92444 views)
  - Headlight Leveling Motors - quattro20v 2010-03-25 13:40:08 (94378 views)
  - How to lobotomize the autocheck lamp warning module (Remove HID bulb out warning)... - EDIGREG 2009-11-15 10:36:53 (100877 views)
    - Cluster fix for erroneous bulb out warning. - GreenMachine 2014-01-13 12:43:06 (59014 views)
    - S4 & S6 Lamp Module <-> Autocheck Wiring Diagrams - quattron8-JC 2012-10-15 23:46:12 (104660 views)
    - Alternate Method 2 - Non-destructive relay mod - S6 version - quattron8-JC 2010-09-24 03:15:37 (87932 views)
    - An alternative method, without modifying the relay... - EDIGREG 2009-11-15 10:39:01 (90939 views)
  - One-touch Up Relay Information: - EDIGREG 2009-10-30 14:14:36 (90082 views)
  - Link to a 53 pg C4 A6 wiring diagram pdf (not UrS but lots of common info) - UrS4boy 2009-10-11 15:23:26 (90387 views)
  - Ignition Switch Replacement: - EDIGREG 2009-10-10 15:35:51 (89427 views)
  - Audi TT HID Low-Beam Retrofit: - EDIGREG 2009-10-10 15:16:16 (90816 views)
  - Headlight Cleaning Procedure: - EDIGREG 2009-10-10 14:35:51 (90153 views)
- DRIVETRAIN - EDIGREG 2009-10-10 12:53:00 (89034 views)
  - Rear Differential Lock Info - ThetaTau87 2013-03-20 09:15:58 (68379 views)
  - Driveshaft Info including links to replacement centre bearings, CV joints and DIYs - ThetaTau87 2013-03-20 09:06:34 (68861 views)
  - Transmission, Clutch and Flywheel info - ThetaTau87 2013-03-20 09:04:59 (69502 views)
  - Clutch Slave cylinder R&R info - Action Jackson 2013-02-15 06:42:14 (69504 views)
  - Rear Differential Seal R&R: - EDIGREG 2012-08-14 02:21:00 (74417 views)
    - '92-95 left seal is 017525400A; 95.5+ is 017525400C - john.eding 2018-12-24 15:19:53 (13278 views)
  - Comparison of 5 spd versus 6 spd 01E gears CBD, CBL and CYT - UrS4boy 2012-05-20 09:17:21 (75999 views)
  - 01E EDU 6-Speed Rebuild Parts List - islingtonaudi 2012-03-26 04:55:21 (77689 views)
  - UrS4 master cylinder replacement - sbitch 2012-02-08 10:55:44 (77576 views)
  - Manual Transmission, Front/Center Differential and Rear Differential Fluid Changing Procedure - UrSobsessed 2010-12-02 13:24:32 (92822 views)
  - Transmission shift linkage adjustment - UrS4boy 2010-11-06 06:11:15 (87090 views)
  - Clutch master cylinder replacement - quattro20v 2010-06-08 06:14:28 (88900 views)
    - Master Cylinder Replacement (Fred Munro) - GreenMachine 2015-07-20 09:52:51 (38264 views)
  - Rear axle replacment DIY. - turbos4audi 2010-02-09 03:45:15 (90581 views)
  - Clutch Replacement procedure: - EDIGREG 2009-12-30 08:34:09 (91194 views)
  - 5 & 6-speed 01E Transmission Identification, Ratios, and General Information: - EDIGREG 2009-11-12 13:46:40 (92510 views)
  - Driveshaft R&R: - EDIGREG 2009-10-10 15:42:10 (90148 views)
- CLIMATE CONTROL - EDIGREG 2009-10-10 12:52:49 (90235 views)
  - Servicing the AC on a 1995.5 S6 - Audicted (refugee) 2022-07-31 13:04:02 (2541 views)
  - Interchangeability of CC head Unit with other models - Audicted (refugee) 2022-04-08 18:11:11 (3291 views)
  - Climate Control: replacing incandescent bulbs with LEDs - KBATTPO 2015-12-18 17:19:36 (33628 views)
  - Changing the Temp Display from F to C, etc. - GreenMachine 2015-01-26 18:53:21 (44566 views)
  - A/C Condensers R-12 VS R-134a - MarvelousS4 2013-07-05 22:44:18 (65755 views)
  - A/C service port addition for R-12 system. - MarvelousS4 2013-07-05 16:27:53 (65732 views)
  - A/C Climate Control Pollen Filter Info - UrS4boy 2012-06-01 03:40:51 (75282 views)
  - Climate control button repair - ThetaTau87 2010-08-11 09:24:25 (87441 views)
  - Climate Control Wiring Diagram 2 of 2 (sorry only lo res but in color!) - ImQuattro�� 2010-05-03 13:14:20 (99725 views)
  - Climate Control Wiring Diagram 1 of 2 (sorry only lo res but in color!) - ImQuattro�� 2010-05-03 13:12:48 (107485 views)
  - Climate Control Plug Identification - ImQuattro�� 2010-05-03 13:11:20 (90017 views)
  - Climate Control Component Location - ImQuattro�� 2010-05-03 13:10:24 (92358 views)
  - Climate Control Fan Control Unit Location - ImQuattro�� 2010-05-03 13:08:48 (90040 views)
  - Climate Control Diagnostic Channel 52 Legend - ImQuattro�� 2010-05-03 13:05:46 (92463 views)
  - Climate Contol Codes & Channel Diagnostics - ImQuattro�� 2010-05-03 02:47:49 (90805 views)
  - How to enable the recirculation button to work independently... - EDIGREG 2010-01-16 16:43:06 (91088 views)
    - Additional info on climate control headunit coding. - Brdman* 2012-11-11 04:15:35 (71923 views)
  - HVAC LCD/CONTROL R&R (sticky button syndrome) - sbitch 2009-11-10 02:55:30 (90567 views)
  - Improved Heater Core DIY pdf with photos and more hints - UrS4boy 2009-10-20 13:50:07 (91230 views)
    - A few hints and details to add to the most excellent Rev. 1 document - tigerwillow1 2021-08-30 19:45:38 (4452 views)
    - A comparison of Meyle and Behr heater cores. - KBATTPO 2020-08-13 02:23:00 (6948 views)
    - The original "2.5 hr" heater core procedure (by kinderutz) - UrS4boy 2011-09-08 12:02:03 (80876 views)
  - Temperature Flap Servo R&R - UrS4boy 2009-10-18 13:16:26 (90486 views)
    - Link to working HVAC servo repair DIY (quattro8's below doesn't work anymore) - UrS4boy 2017-09-01 11:34:48 (20702 views)
    - Climate servo rehab/cleaning procedure - quattro8 2010-10-04 10:27:46 (87124 views)
  - HVAC Blower Motor R&R: - EDIGREG 2009-10-14 09:09:09 (91456 views)
- COOLING SYSTEM - EDIGREG 2009-10-10 12:52:32 (89875 views)
  - Metal Thermostat Upgrade Part # - Cash68 2015-03-02 06:13:39 (43387 views)
    - Sources for the metal T fitting and block coolant flange. - GreenMachine 2018-09-09 13:00:19 (14828 views)
  - C4 AAN Cooling and Heating System (with hyperlinks to more info) - Cash68 2015-02-12 11:53:25 (44985 views)
  - Climate control coolant Tee PN with Coolant Temp Sender, O-ring and clip PNs and more - Cash68 2015-02-12 10:06:45 (43801 views)
  - Aux Fan part # - WVUrS6 2013-05-29 10:52:30 (66311 views)
  - F76 Multifunction Temperature Switch R&R Info - ThetaTau87 2013-03-20 12:29:06 (68557 views)
  - Coolant Expansion Tank/Reservoir Info - ThetaTau87 2013-03-20 08:54:41 (68074 views)
  - Viscous Clutch Fan Info (mostly bearing info) - ThetaTau87 2014-12-26 15:01:51 (68295 views)
  - Coolant comparison of G12 vs Dexcool vs "Green stuff" - Cash68 2011-07-18 09:28:48 (82415 views)
  - G62 Coolant Temp sensor Info - EDIGREG 2011-01-31 15:12:36 (85881 views)
  - After-run Auxiliary Coolant Pump and Switch Info - EDIGREG 2011-01-31 15:09:29 (86292 views)
  - Coolant Reservoir, Radiator and Coolant PNs - EDIGREG 2011-01-31 15:09:11 (85265 views)
  - Multifunction Temperature Switch R&R Info (with Cross Links to G62 Coolant Temp Sensor) - EDIGREG 2011-01-31 15:08:28 (85008 views)
  - Thermostat Diagnostic and Replacement Procedures - EDIGREG 2011-01-31 15:08:06 (85276 views)
  - Cooling system hose, sensor and hardware info. - UrSobsessed 2009-11-15 15:52:21 (93137 views)
  - After-run pump R&R: - EDIGREG 2009-10-20 08:43:27 (89718 views)
- BRAKES - EDIGREG 2009-10-10 12:52:21 (89515 views)
  - SJM Brake Troubleshooting - ABS, Accumulator aka Bomb - audipete 2024-03-21 14:42:51 (70 views)
  - Brake light Switch part No 1995.5 S6...uses a 4 pin switch 4A0945515A...early models 2 pin 443945515 - Audicted (refugee) 2022-05-24 15:20:12 (2975 views)
  - D2 S8 rear caliper 'upgrade' - urs6Josh 2020-12-16 09:39:58 (6408 views)
  - Rob Edward's (Rennlist) Brembo Caliper rebuild DIY - UrS4boy 2016-08-25 07:15:03 (27775 views)
  - Replacing the brake pressure accumulator aka the bomb - quattro20v 2016-07-13 19:40:03 (29651 views)
  - DIY Power Bleeder On The Cheap... - islingtonaudi 2013-07-19 22:45:21 (66106 views)
  - E-brake cable adjustment and PN info - ThetaTau87 2013-03-20 09:07:52 (68356 views)
  - How our C4 UrS Power Brake System Works - ThetaTau87 2013-03-20 08:46:07 (68763 views)
  - Rear calipers rebuilding (from P.D.Q. on Audiworld) - MatLax 2011-06-29 03:06:44 (88134 views)
  - C4 UrS4/S6 Front Brake Options - GreenMachine 2011-05-30 13:18:14 (86529 views)
  - DIY: Vacuum brake booster conversion - MatLax 2010-11-17 13:04:39 (89337 views)
    - A List of Parts Required for Converison - pltfn 2015-12-07 03:28:32 (34167 views)
      - Add 1 more seal for master cylinder to vacuum booster - running_cold924 2017-10-05 12:32:38 (19886 views)
  - Part No.'s for the 993tt or 928GTS Brembo Big Brake Upgrade with RS2 brackets - UrS4boy 2010-11-07 03:48:01 (88153 views)
  - ABS Defeat Switch Modification (for non '92 S-cars) - GreenMachine 2010-01-23 19:08:05 (90002 views)
  - Brake Servo Replacement procedure: - EDIGREG 2009-12-30 08:28:37 (89965 views)
  - One Rear Brake Caliper R & R procedure (updated Dec. 2/13) - UrS4boy 2009-10-25 02:40:21 (99243 views)
  - Repairing Seized Rear Caliper Guide Pins: - EDIGREG 2009-10-10 15:25:06 (90380 views)
    - archived. - ejg3855 2015-11-18 11:17:22 (34320 views)
- BODY - EDIGREG 2009-10-10 12:52:11 (88892 views)
  - Outside Mirror Glass Heating Diagnosis - GreenMachine 2019-11-22 19:40:44 (10340 views)
  - Replacing the gas spring in the elbow rest - KBATTPO 2017-03-14 16:36:42 (23367 views)
  - Modifying the avant hatch handle to allow the installation for the euro center tail - speedydtp247 2015-12-03 17:07:45 (34256 views)
  - Replacing Driver's Side Door Glass Removal and Replacement DIY pdf - UrS4boy 2015-04-19 22:46:37 (41092 views)
  - Trunk lock actuator vacuum leak repair procedure - KBATTPO 2014-08-01 10:11:51 (52532 views)
    - OEM VW/Audi Repair Boots ($5.99) - GreenMachine 2018-04-26 12:48:32 (16846 views)
  - Mirror glass replacement - c4S6 2013-10-08 21:08:12 (62180 views)
  - Replacing the oval Audi emblem on the front fender - ThetaTau87 2013-03-20 09:03:32 (68008 views)
  - Hood Release: How it works, why it fails and how to fix it. - ThetaTau87 2013-03-20 08:44:59 (68169 views)
  - Front Door Lock and Window info - ThetaTau87 2013-03-20 08:32:52 (68357 views)
  - Front door window R&R - MarvelousS4 2012-06-23 16:10:07 (74563 views)
  - C4 Bumper differences 100/S4 and A6/S6, Euro and NAmerica - UrS4boy 2012-05-03 18:12:16 (76221 views)
  - C4 UrS-car Cowl Drain Issues and their solutions - UrS4boy 2011-11-20 03:07:33 (79217 views)
    - Water in footwell from failed A pillar/windshield cowl seam sealer - audipete 2023-07-10 17:31:41 (751 views)
  - Adjusting the trunk lid - EDIGREG 2011-05-08 12:46:37 (83670 views)
  - Frankenmirror mod (swapping the late C4 mirror from "Nemo" to full size) - boxflares 2010-10-26 05:55:55 (94596 views)
    - Some notes along with pictures from the creator of the original Frankenmirror mod - KBATTPO 2016-01-28 09:15:12 (32454 views)
  - USA C4 Paint / Color Codes by Model Year - boxflares 2010-06-07 21:48:37 (88459 views)
    - All the C4 Paint Codes (including the UrS) with the interior codes (for Build Tag Decoding) - UrS4boy 2017-02-01 15:35:56 (24606 views)
    - 1995.5 MY (07-01-95 to 12-31-95) - boxflares 2010-06-07 22:20:30 (88952 views)
    - 1995 MY (07-01-1994 to 07-31-1995) - boxflares 2010-06-07 22:15:24 (88482 views)
    - 1994 MY (07-01-1993 to 07-31-1994) - boxflares 2010-06-07 22:05:01 (88303 views)
    - 1993 MY (07-01-1992 to 07-31-1993) - boxflares 2010-06-24 02:39:48 (88119 views)
    - 1992 MY (01-1-1992 to 07-31-1992) - boxflares 2010-06-07 21:56:02 (87826 views)
  - Towing Capacity - boxflares 2010-04-12 01:10:25 (89712 views)
  - Sunroof Drain - yaminator 2010-01-20 20:42:29 (90779 views)
  - Trunk lock rehab or swap. - turbos4audi 2009-12-31 12:33:05 (89750 views)
    - Late model C4 avant rear hatch lock cylinder R+R - shmcquilkin 2014-08-10 14:50:39 (51986 views)
  - Location of front and rear UrS badges - UrS4boy 2009-11-10 00:40:56 (94278 views)
    - New UrS badges - speedydtp247 2010-08-09 16:57:33 (87653 views)
      - Another source for UrS badges - speedydtp247 2015-06-08 20:00:00 (83415 views)
  - Vented Wheel Well Liner Modification (Frankenliner): - EDIGREG 2009-10-10 15:22:03 (89941 views)
    - Updated link, the s-cars one is dead. - AustinEngy 2021-11-29 00:06:29 (3946 views)
- AUDIO / ELECTRONICS - EDIGREG 2009-10-10 12:51:55 (89640 views)
  - Coding a Concert Radio for Bose - GreenMachine 2017-07-26 18:44:44 (21373 views)
  - C4 Sedan ('94) and Urs6 Avant Antenna Mast Information - GreenMachine 2015-05-08 15:10:48 (44884 views)
    - Update on Avant Antenna - nick.cfrancis 2023-10-08 18:07:34 (512 views)
  - 5.25" front speaker bracket template - PLANETARY4 2013-02-25 12:54:56 (68718 views)
  - Gamma CC and Delta CC info including reset info and GALA for the Delta - UrS4boy 2012-09-09 05:50:19 (73333 views)
  - C4 Radio Cage Differences and why - UrS4boy 2012-05-20 06:54:00 (75414 views)
  - Jimmy Pribble's Bosectomy - GreenMachine 2011-07-17 00:23:44 (82925 views)
  - Avant Radio antenna / reception improvements - quattro8 2010-10-04 08:22:10 (91692 views)
  - Gamma Radio Pinout Diagram: - EDIGREG 2009-10-10 14:33:39 (100150 views)
  - Installing an Auxiliary Stereo Input: - EDIGREG 2009-10-10 13:10:18 (91161 views)
  - Summary of Audi Radios (Which Radio Do I Have?) - EDIGREG 2009-10-10 13:08:35 (91003 views)
  - Phatnoise Adapter Install: - EDIGREG 2009-10-10 13:07:56 (90079 views)
  - Concert Head Unit Install: - EDIGREG 2009-10-10 13:07:19 (90600 views)
    - ^^^This method is now obsolete. A plug and play relay swap allows a simple, clean install. - GreenMachine 2016-06-27 19:22:23 (29523 views)
    - Just a note: CD Changer won't work if Installing a Concert in place of any Delta/Gamma - ImQuattro�� 2010-10-13 07:27:14 (86099 views)
- ALARM SYSTEM - EDIGREG 2009-10-10 12:51:44 (90013 views)
  - '95.5 Urs6 Defa Remotes Ordering Info - GreenMachine 2018-03-13 10:55:18 (17402 views)
    - Defa/Audi Antenna Box - GreenMachine 2019-08-29 15:38:33 (10723 views)
  - Central Locking Actuator Rubber Boot Replacement with Alternative Bosch part - TheCrispyNoodle 2016-04-09 06:04:32 (33270 views)
    - OEM VW/Audi Repair Boots ($5.99) - GreenMachine 2018-04-28 14:14:05 (16679 views)
      - As of 23 Aug, 2018 these are no longer available from T3 Technique. - markiteight 2018-08-23 22:53:01 (14964 views)
  - Additional info on R&R of the central locking pump - TheCrispyNoodle 2016-04-03 10:58:55 (31334 views)
  - Rundown of the 3 different C4 Alarm/Central Locking Systems (Pumps, Keys, and Remotes) - GreenMachine 2015-02-13 09:53:39 (56333 views)
  - C4 100/UrS4 Infrared Remote Key - Batteries and Reprogramming - UrS4boy 2012-08-13 04:10:53 (87854 views)
  - RF Remote Programming FAQ - iduff 2011-10-01 02:07:55 (81796 views)
  - 95.5 S6 HAA Key & Remote Replacement Guidelines - quattro8 2010-10-04 08:00:36 (88906 views)
    - I successeflully reprogrammed the wife's old 1998 A4 1.8T key to work with my 1997 S6 and vise versa - KBATTPO 2014-12-26 12:08:59 (46148 views)
  - RightClick Installation Part #'s Wiring colors, Lighting, and trunk release info pictures - ImQuattro�� 2010-02-17 10:56:34 (111074 views)
    - New RightClick link inside - speedydtp247 2023-10-22 21:44:57 (537 views)
    - HU49 is the key blank you need for the 92-95 UrS4/6. HU66 is the one you need for 95.5-97 UrS6 - speedydtp247 2010-08-08 14:53:44 (87992 views)
  - Right Click RF Keyless Entry System KE60W installation - sbitch 2009-11-08 00:09:06 (91114 views)
- AIRBAG / SAFETY FEATURES - EDIGREG 2009-10-10 12:51:17 (89838 views)
  - ProCon-Ten passive restraint activation system info - ThetaTau87 2013-03-20 08:43:25 (67742 views)
  - Airbag Control Modules and Diagnostic Connectors: - EDIGREG 2009-10-11 12:27:59 (90241 views)

You must be registered and logged in to post. Please select an option:

All messages | Search Forums | Return to UrS4/UrS6/S2/RS2

Copyright © VerticalScope Inc. All rights reserved.

quattroworld.com is an independent Audi enthusiast website owned and operated by VerticalScope Inc. Content on quattroworld.com is generated by its users. quattroworld.com is not in any way affiliated with Audi AG.